Ford and Nissan Blow Chevy, Toyota Away When It Comes To Safety
March 21st, 2019
The latest IIHS report shows that overall, most pickups need better passenger-side protection. However, when it comes to safety, Ford and Nissan both stood out. The Ford F-150 and the Nissan Titan earned a good rating.
*Note: the Institute only used crew cab versions of the trucks tested.
In total, IIHS has rated 11 crew cab pickups in the passenger-side test — four small and seven large. The Toyota Tundra, a large pickup, earns the only poor rating, while five of the trucks rate marginal.
"We commend Ford, Nissan and Ram for providing state-of-the-art crash protection for both drivers and front passengers of their large pickup models," says David Zuby, IIHS chief research officer. "As a group, however, the pickup class still has a lot of work to do."
A small overlap crash occurs when just the front corner of the vehicle strikes another vehicle or an object such as a tree or utility pole. IIHS began rating vehicles for protection in a driver-side small overlap front crash in 2012. In 2017, the Institute launched the passenger-side test to make sure occupants on both sides of the vehicle get equal protection.
Pickups took longer than other vehicle categories to meet the Institute's challenge for driver-side small overlap protection, so it's no surprise that they are lagging a bit in the newer passenger-side evaluation. Today most pickups earn a good rating in the driver-side test.
A front crash test represents a much more severe crash for a pickup than for smaller vehicles because the severity of a crash into a fixed barrier depends on the weight of the vehicle.
The Ford F-150 was the best performer in the passenger-side test. The structure held up well with maximum intrusion of 5 inches at the rightmost section of the toepan. The seat belts and airbags worked well together to control the movement of the passenger and driver dummies, and neither dummy recorded any potential injuries.
The Tundra, in contrast, was seriously compromised by intruding structure. Maximum intrusion, also at the rightmost part of the toepan, measured 15 inches. There was also intrusion of more than a foot at the lower door hinge pillar. The passenger dummy's head hit the grab handle attached to the A-pillar as the A-pillar intruded into the passenger's space.
Measures taken from the dummy indicate that injuries to the right lower leg would be likely in a crash of this severity, and injuries to the right hip would be possible.
The Tundra and the Nissan Frontier, which earns a marginal rating in the passenger-side test, are still struggling with the driver-side small overlap test. Both earn a marginal rating for driver-side protection. These trucks have the oldest designs in the test group. The Frontier's basic structure dates back to the 2005 model year, while the Tundra's is from 2007.